Product ID:NAPA ND 30, 00075115
MSDS Date:11/07/1991
FSC:9150
NIIN:00N070743
MSDS Number: CBMLX

VALVOLINE INC

LEXINGTON, KY 40512
US

Emergency Phone: 800-274-5263

Info Phone: 606-264-7000

Cage: GO029

VALVOLINE OIL CO

14000 LEXINGTON, KY 40512 US

Telephone: 606-357-7206 / 800-274-5263

Cage: 72527

SOLVENT DEWAXED RESIDUAL OIL (PETROLEUM); (PETROLEUM OIL)

CAS: 64742-62-7

Fraction By Weight: 25-40%

OSHA PEL N/K

ACGIH TLV: N/K

SEVERELY HYDROTREATED HYDROCARBON OIL (ALSO CAS #72623-85-9

CAS: 72623-87-1

Fraction By Weight: 70-85%

OSHA PEL 5 MG/M3 (MFR)

ACGIH TLV: 5 MG/M3 (MFR)

SHOULD BE EXCLUDED FROM AREA OF SPILL UNTIL

RTECS: 9999999ZZ

AREA OF SPILL TO PVNT SPREADING, PUMP LIQ TO SALV

RTECS: 9999999ZZ

EARTH, FLOOR ABSORBENT, OR OTHER ABSORBENT MATERIAL

RTECS: 9999999ZZ

LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:PROD IS NOT HAZ AS DEFINED BY OSHA (29
CFR 1910.1200) BASED ON TESTING OF SIMILAR PRODS &/OR COMPONENTS.
EYES:NOT EXPECTED TO CAUSE IRRIT DURING NORMAL CNDTNS OF USE.
SKIN:PRLNGD/RPTD CONT MAY BE MILD LY IRRIT TO SKIN & MAY CAUSE
DERM. INGEST:NOT EXPECTED TO BE TOX. PROD HAS LAXATIVE PROPERTIES &
MAY (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZS:CAUSE NAUS, ABDOM CRAMPS & DIARR.
INHAL:NOT EXPECTED TO BE A HAZ AT NORMAL ROOM TEMP. HOWEVER, IF
EXPOS EXCEED PEL/TLV OF 5 MG/M3 FOR OIL MIST, THEN INHAL OF MIST
MAY RSLT IN RESP IRRIT & PO SS DISCOMFORT. CHRONIC:NONE CURRENTLY
KNOWN FOR PROD. CAUTN:USED MOTOR OIL HAS BEEN SHOWN TO CAUSE SKIN
CANCER (SUP DAT)
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.

First Aid:SKIN:THORO WASHED EXPOSED AREA W/SOAP & WATER. REMOVE CONTAM
CLTHG & LAUNDER BEFORE REUSE. EYES:FLUSH W/LG AMTS OF WATER,
LIFTING LIDS OCCAS. GET MED ATTN, IF IRRIT PERSISTS. INGEST:DO NOT
INDUCE VOMI T, KEEP PERSON WARM & QUIET, & GET MED ATTN.
INHAL:REMOVE INDIVIDUAL TO FRESH AIR. IF BRTHG IS DFCLT, ADMIN
OXYG. IF BRTHG HAS STOPPED GIVE ARTF RESP. KEEP PERSON WARM, QUIET
& GET MED ATTN.

Flash Point Method:COC
Flash Point:>430F,>221C
Extinguishing Media:REGULAR FOAM OR CARBON DIOXIDE OR DRY CHEMICAL.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPRVD SCBA & FULL PROT EQUIP
. WATER/FOAM MAY CAUSE FROTHING WHICH CAN BE VIOLENT & POSS
ENDANGER LIFE OF FIREFIGHTER, ESP IF (SUPP DATA)
Unusual Fire/Explosion Hazard:NEVER USE WELDING OR CUTTING TORCH ON OR
NEAR DRUM (EVEN EMPTY) BECAUSE PRODUCT (EVEN JUST RESIDUE) CAN
IGNITE EXPLOSIVELY.

Spill Release Procedures:SM SPILL:ABSORB LIQ ON PAPER, VERMICULITE,
FLOOR ABSORB/OTHER ABSORB MATL. LG SPILL:PVNT RUN-OFF TO SEWERS,
STREAMS/OTHER BODIES OF WATER. IF RUN-OFF OCCURS, NOTIFY PROPER
AUTHS AS REQ, THAT SPILL HAS OCCURED. PERSONS NOT WEARING PROT
EQUIP (ING 3)
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.

Handling and Storage Precautions:DO NOT TRANSFER TO UNLBLED CNTNR. DO
NOT USE CUTTING/WELDING TORCH ON CNTNR (EVEN EMPTY). FOR INDUST USE
ONLY.
Other Precautions:BEFORE USE, REVIEW MSDS FOR MORE DETAILED INFO,
INCLUDING CHRONIC HLTH EFTS. 24-HR EMER # 1-800-274-5263. CNTNRS OF
MATL MAY BE HAZ WHEN EMPTIED SINCE THEY RETAIN PROD RESIDUES (VAP,
LIQ &/OR SOLID), ALL HAZ PRECS MUST BE OBSERVED.

Respiratory Protection:NOT REQ UNDER NORMAL CNDTNS OF USE. HOWEVER, IF
OIL MISTS ARE GENERATED ABOVE REC PEL/TLV OF 5 MG/M3, THEN
NIOSH/MSHA APPRVD RESP IS ADVISED IN ABSNECE OF PROPER
ENVIRONMENTAL CONTROL. (SEE YOUR SAFET Y EQUIPMENT SUPPLIER).
Ventilation:NOT REQ UNDER NORMAL CNDTNS OF USE. HOWEER, IF UNUSUAL
OPERATING CNDTNS EXIST, THEN PROVIDE SUFFICIENT MECH (SUPP DATA)
Protective Gloves:RESIST GLOVES SUCH AS NITRILE RUBBER.
Eye Protection:ANSI APPROVED CHEM WORKERS GOGGS .
Other Protective Equipment:ANSI APPROVED EMERGENCY EYE WASH AND DELUGE
SHOWER . NORMAL WORK CLOTHING COVERING ARMS AND LEGS.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
FIRE FIGHT PROC:SPRAYED INTO CNTNRS OF HOT, BURNING LIQ. DENSE SMK MAY
BE GENERATED WHILE BURNING. EFTS OF OVEREXP:IN CERTAIN LAB ANIMALS
CONTINUALLY EXPOSED TO USED MOTOR OIL BY RPTD APPLICATNS. AVOI D
PRLNGD/RPTD CONT TO SKIN. VENT:(GEN &/OR LOC EXHST) VENT TO
MAINTAIN EXPOS BELOW PEL/TLV(S).

Boiling Pt:B.P. Text:575F,302C
Vapor Density:HVR/AIR
Spec Gravity:0.889 @ 60F
Evaporation Rate & Reference:SLOWER THAN ETHER
Appearance and Odor:LIGHT AMBER LIQUID IN HOMOG SOLUTION FORM.

Stability Indicator/Materials to Avoid:YES
AVOID CONTACT WITH:STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:NONE SPECIFIED BY MANUFACTURER.

Waste Disposal Methods:SMALL AND LARGE SPILLS:DISPOSE OF IN ACCORDANCE
WITH ALL LOCAL, STATE AND FEDERAL REGULATIONS.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.